Call Us
Book Today
Able Plumbing & Electrical Able Plumbing & Electrical Able Plumbing & Electrical
  • Fast Local Service across Butte, Sutter, Yuba, Tehama & Glenn Counties:
  • Call Able Plumbing & Electrical:
  • CALL: 530-564-1023

It's & We're Always Open

ph
ph

Chico Polybutylene Repipe Plumbers

CHICO, YUBA CITY, OROVILLE, PARADISE

Polybutylene is a form of plastic resin that was used extensively in the manufacture of water supply piping from 1978 until 1995. Due to the low cost of the material and ease of installation, polybutylene piping systems were viewed as "the pipe of the future" and were used as a substitute for traditional copper piping. It is most commonly found in the "Sun Belt" where residential construction was heavy through the 1980's and early-to-mid 90's, but it is also very common in the Mid Atlantic and Northwest Pacific states.

Polybutylene Piping

These are typically gray or white in color with a dull finish.

The piping systems were used for underground water mains and as interior water distribution piping. Industry experts believe it was installed in at least 6 million homes, and some experts indicate it may have been used in as many as 10 million homes. Most probably, the piping was installed in about one in every four or five homes built during the years in which the pipe was manufactured.

How to Tell If You Have Poly

Interior - Polybutylene used inside your home can be found near the water heater, running across the ceiling in unfinished basements, and coming out of the walls to feed sinks and toilets. Warning: In some regions of the country plumbers used copper "stub outs" where the pipe exits a wall to feed a fixture, so seeing copper here does not mean that you do not have poly.

Exterior - Polybutylene underground water mains are usually blue, but may be gray or black (do not confuse black poly with polyethelene pipe). It is usually 1/2" or 1" in diameter, and it may be found entering your home through the basement wall or floor, concrete slab or coming up through your crawlspace; frequently it enters the home near the water heater. Your main shutoff valve is attached to the end of the water main. Also, you should check at the water meter that is located at the street, near the city water main. It is wise to check at both ends of the pipe because we have found cases where copper pipe enters the home, and poly pipe is at the water meter. Obviously, both pipes were used and connected somewhere underground.

Will the Pipes Fail?

While scientific evidence is scarce, it is believed that oxidants in the public water supplies, such as chlorine, react with the polybutylene piping and acetal fittings causing them to scale and flake and become brittle. Micro-fractures result, and the basic structural integrity of the system is reduced. Thus, the system becomes weak and may fail without warning causing damage to the building structure and personal property. It is believed that other factors may also contribute to the failure of polybutylene systems, such as improper installation, but it is virtually impossible to detect installation problems throughout an entire system.

Throughout the 1980's lawsuits were filed complaining of allegedly defective manufacturing and defective installation causing hundreds of millions of dollars in damages. Although the manufacturers have never admitted that poly is defective, they agreed to fund the Class Action settlement with an initial and minimum amount of $950 million - thousands of homeowners took advantage of this program through Able Plumbing alone.Able Plumbing was the authorized contractor under this settlement serving all of California north of Sacramento. Unfortunately, the claims period for this settlement has run its course. For mobile home repiping, one of the requirements is that the home must have been manufactured (with polybutylene piping) within 11 years of the claims date.

Fortunately, Able Plumbing continues to provide this expert and cost effective service directly to our community.

Our experience, volume and efficiency allows us to provide the highest quality service and materials at very reasonable cost. An Able-Standard replumb of your home would include the following:

  • We will replace all the polybutylene waterlines within your home with your choice of CPVC, Type M Copper, or Type L Copper piping - PEX may also be considered as an alternative material. CPVC is not recommended for homes where rodents have unfettered access to the piping but is generally preferred in all other situations.
  • New brass emergency shutoff valves will be installed at the sinks and toilets.
  • New stainless steel supply lines will be connected to the fixtures.
  • The main water lines will be installed above the moisture barrier for protection. If we install any pipes below the moisture barrier they will be insulated.
  • Any access holes we create in the moisture barrier will be repaired with approved materials and will be attached with contact cement and butterfly staples to insure a permanent repair.
  • Inside your home we will use access panels or cover plates where necessary for shower valve and laundry valve access. This will provide access for future maintenance of your plumbing valves whenever that is necessary.
  • We take care to protect your home while we are there. We provide expert crews for a top quality and efficient project that is almost always completed in a single day for your convenience, but should the job take more than one day we will temporarily connect at least one bathroom.

Call Able Plumbing today for more information.

CALL: 530-564-1023

Northern Sacramento Valley Service Areas

Butte County

Including Chico, Paradise, Oroville and surrounding areas.

Sutter County

Including Yuba City, Live Oak and surrounding areas.

Yuba County

Including Marysville, Olivehurst and surrounding areas.

Tehama County

Including Red Bluff, Corning and surrounding areas.

Glenn County

Including Orland, Willows and surrounding areas.

Why Choose Able Plumbing & Electrical

Satisfaction Guaranteed

With Able Plumbing and Electrical you can be sure of a level of friendly service which is second-to-none, all backed up by a 100% satisfaction guarantee.

Award-winning Service

Rated ‘Best’ by thousands our your neighbors for over 32 years.

Why Choose ABLE PLUMBING & ELECTRICAL
Why Choose ABLE PLUMBING & ELECTRICAL

Fast, Same Day Service

You can rely on us when you need us in an emergency with fast same day service.

On-time Convenience

You can be sure that we'll be there on-time, at a time convenient for you.

Why Choose ABLE PLUMBING & ELECTRICAL

Written Guarantees

All of our workmanship is backed up by a written warranty

24 Hours, 7 Days Emergency Service

Able Plumbing and Electrical is available around the clock for emergencies.

Why Choose ABLE PLUMBING & ELECTRICAL

Satisfied Customers

  • Polite .Punctual. Professional. Total respect of the customer. These things are worth paying for.

    5 Stars rated.
  • Alex was on time, informative, did excellent work in a timely manner, cleaned up after himself and completed all work satisfactorily and on quote!

    5 Stars rated.
  • I appreciate the professionalism and comprehensiveness of Able Plumbing's service.

    5 Stars rated.